Home
About Us
Calendar
Fiero Documents
Merchandise
Tips
Links
Members
Message Board
Other Fiero Clubs
VIN Decoder
Speed Calculator
GFC Facebook Page
 
« previous next »
Pages: 1 ... 10 11 [12] 13 14 ... 20

Author Topic: 3.4 swap runs but sputters smooths out then dies smells very rich  (Read 31216 times)

0 Members and 1 Guest are viewing this topic.

GTRS Fiero

  • Hero Member
  • *****
  • Posts: 12,510
  • It is what it is.
    • View Profile
Re: 3.4 swap runs but sputters smooths out then dies smells very rich
« Reply #165 on: March 31, 2020, 11:16:01 pm »
Yes.
Logged

Sandman87

  • Full Member
  • ***
  • Posts: 223
    • View Profile
Re: 3.4 swap runs but sputters smooths out then dies smells very rich
« Reply #166 on: April 01, 2020, 10:08:05 am »
I put it in still stalls when it's in drive.
Logged
Mike

Sandman87

  • Full Member
  • ***
  • Posts: 223
    • View Profile
Re: 3.4 swap runs but sputters smooths out then dies smells very rich
« Reply #167 on: April 01, 2020, 10:48:10 am »
Update after the engine got warmed up it will run and drive but it bounces around 5 to 700 RPMs and then eventually will chug its way up to 900 RPMs and stay there but then it started chugging again around 5 to 600 RPMs and through check engine codes I believe they are code 22 and code 32 I already replaced the map sensor I have a new air charge sensor on the way
Logged
Mike

Sandman87

  • Full Member
  • ***
  • Posts: 223
    • View Profile
Re: 3.4 swap runs but sputters smooths out then dies smells very rich
« Reply #168 on: April 01, 2020, 10:50:15 am »
Code 22 is for the throttle position sensor I also have one of those on the way
Logged
Mike

Fierofool

  • Global Moderator
  • *****
  • Posts: 10,745
    • View Profile
    • Georgia Fiero Club
Re: 3.4 swap runs but sputters smooths out then dies smells very rich
« Reply #169 on: April 01, 2020, 11:50:14 am »
Sorry I can't be of much help.  I'm playing school teacher this week.
Logged
There are three kinds of men:

1.    The ones that learn by reading.
2.    The few who learn by observation.
3.    The rest of them have to pee on the electric fence and find out for themselves.    Will Rogers

Sandman87

  • Full Member
  • ***
  • Posts: 223
    • View Profile
Re: 3.4 swap runs but sputters smooths out then dies smells very rich
« Reply #170 on: April 01, 2020, 03:03:14 pm »
You're all good buddy the help of already received from you has been great
Logged
Mike

GTRS Fiero

  • Hero Member
  • *****
  • Posts: 12,510
  • It is what it is.
    • View Profile
Re: 3.4 swap runs but sputters smooths out then dies smells very rich
« Reply #171 on: April 08, 2020, 06:26:38 pm »
Parts come in, yet?
Logged

Sandman87

  • Full Member
  • ***
  • Posts: 223
    • View Profile
Re: 3.4 swap runs but sputters smooths out then dies smells very rich
« Reply #172 on: April 23, 2020, 06:35:07 am »
yeah running better but not 100 percent im looking for a egr vacuum solenoid cant seem to find it .throwing code 32 getting ramdom sputtering and poping if anyine is selling a good one im your buyer 
Logged
Mike

TopNotch

  • The Duke of URL
  • Global Moderator
  • *****
  • Posts: 3,984
    • View Profile
Re: 3.4 swap runs but sputters smooths out then dies smells very rich
« Reply #173 on: April 23, 2020, 08:03:06 am »
I have an EGR solenoid. It's missing that little hose that's so often a problem on those, though.
Logged
The more complex the mind, the greater the need for the simplicity of play.

Fierofool

  • Global Moderator
  • *****
  • Posts: 10,745
    • View Profile
    • Georgia Fiero Club
Re: 3.4 swap runs but sputters smooths out then dies smells very rich
« Reply #174 on: April 23, 2020, 08:07:07 am »
The EGR solenoid won't cause any issues with the way the car runs even if it sets a code.  The popping is caused by other issues. 

The check engine light can be an annoyance, but it will come on and go off as you drive it, if it's only caused by the EGR system.  If you can wait long enough, I will be freeing up a solenoid in a month or so, as my 7730 conversion takes place. 

Did you replace the fuel filter with the new injectors install?  I'm having what I thought was a misfire but could be described as sputtering and popping.  It begins at about a half tank of fuel and gets worse as the fuel level drops.  I am now theorizing that it's caused by a bad pump to outlet hose that begins sucking air as the fuel level drops below it.  Filling the tank causes the problem to go away.  Do you have a full tank of fuel?

Pat, I have a piece of hose that we can install before shipping. 
Logged
There are three kinds of men:

1.    The ones that learn by reading.
2.    The few who learn by observation.
3.    The rest of them have to pee on the electric fence and find out for themselves.    Will Rogers

GTRS Fiero

  • Hero Member
  • *****
  • Posts: 12,510
  • It is what it is.
    • View Profile
Re: 3.4 swap runs but sputters smooths out then dies smells very rich
« Reply #175 on: April 23, 2020, 08:10:45 am »
Supposedly, it's no biggie to find that hose.  Not sure what type of hose it is, though.
Logged

Fierofool

  • Global Moderator
  • *****
  • Posts: 10,745
    • View Profile
    • Georgia Fiero Club
Re: 3.4 swap runs but sputters smooths out then dies smells very rich
« Reply #176 on: April 23, 2020, 08:15:39 am »
I have been replacing them for years with a length of fish tank aerator hose from my daughter's old fish tank.  The hose is almost gone.  I'm down to less than a foot.  Of course, she had the fish when she was in high school, over 20 years ago. 
Logged
There are three kinds of men:

1.    The ones that learn by reading.
2.    The few who learn by observation.
3.    The rest of them have to pee on the electric fence and find out for themselves.    Will Rogers

GTRS Fiero

  • Hero Member
  • *****
  • Posts: 12,510
  • It is what it is.
    • View Profile
Re: 3.4 swap runs but sputters smooths out then dies smells very rich
« Reply #177 on: April 23, 2020, 08:17:41 am »
That clear hose?
Logged

Fierofool

  • Global Moderator
  • *****
  • Posts: 10,745
    • View Profile
    • Georgia Fiero Club
Re: 3.4 swap runs but sputters smooths out then dies smells very rich
« Reply #178 on: April 23, 2020, 08:25:12 am »
It was clear.  It's now aged to a nice lager beer amber color.  Sometimes the problem isn't the solenoid, but the little rubber piece that connects the hard plastic line to the solenoid.  It rots, becomes porous and loses its ability to hold a vacuum.  A little piece of the vinyl hose as a replacement solves the problem.
« Last Edit: April 23, 2020, 08:27:52 am by Fierofool »
Logged
There are three kinds of men:

1.    The ones that learn by reading.
2.    The few who learn by observation.
3.    The rest of them have to pee on the electric fence and find out for themselves.    Will Rogers

GTRS Fiero

  • Hero Member
  • *****
  • Posts: 12,510
  • It is what it is.
    • View Profile
Re: 3.4 swap runs but sputters smooths out then dies smells very rich
« Reply #179 on: April 23, 2020, 08:25:59 am »
For the people who tried it, how long does it last in use?
Logged
Pages: 1 ... 10 11 [12] 13 14 ... 20
« previous next »